Retained Catheter Fragment After Continuous Paravertebral Block Placement for Thoracoscopic Repair of Tracheoesophageal Fistula of a Neonate: A Case Report.

backgroundThoracic paravertebral catheters are increasingly used in neonates to avoid neuraxial techniques during thoracoscopic tracheoesophageal fistula (TEF) repair. Catheter fracture and retention are exceedingly rare in this population, and optimal management remains undefined. LEARNING

objectivesRecognize this complication risk in neonatal paravertebral placement; identify appropriate imaging when retention is suspected; discuss conservative and surgical approaches; and understand the importance of early transparent communication with caregivers. CASE: A 2-day-old term neonate weighing 2.90 kg underwent thoracoscopic repair of type C tracheoesophageal fistula with intraoperative placement of an ultrasound-guided right paravertebral catheter for continuous analgesia. The catheter was placed at the T5 vertebral level using a 20 G, 2-inch Tuohy needle with an in-plane lateral-to-medial approach. Saline hydrodissection was used to confirm entry into the paravertebral space. A 24 G radiopaque Perifix One catheter was initially inserted but proved difficult to advance. During attempted removal, some resistance was encountered, and both the needle and catheter were withdrawn together. Subsequent inspection suggested possible catheter shortening, raising concern for a retained fragment. A second catheter of size 20 G advanced via an 18 G needle was then successfully placed at the same level and was removed without complications on postoperative day 3. Comparison with an intact reference catheter revealed that the first-placed 24 G catheter was approximately 1.5 cm shorter, although the tip appeared intact. The pain physician promptly notified both the clinical teams and the family. One month later, during routine imaging for respiratory distress, a curvilinear opacity was noted at the T9 vertebral level. Dedicated thoracic spine films confirmed a 7 mm retained paravertebral catheter fragment. Multidisciplinary consensus (pain team, anesthesia, NICU, and surgery) determined that the fragment was small, non-metallic, and remote from critical structures. Conservative management with long-term follow-up was chosen. The family was informed early during initial suspicion and again upon confirmation. At 17-month follow-up, the child remained asymptomatic. DISCUSSION: Retained catheter fragments are rare in pediatric regional anesthesia and may be radiographically occult early. In neonates, re-operation for a tiny, inert foreign body may cause more morbidity than observation. Prevention depends on appropriate equipment selection, catheter integrity checks pre- and post-placement, careful technique, and attention to resistance or difficulty during advancement or removal. Clear and timely communication with caregivers preserves trust when complications or iatrogenic uncertainty arise.

conclusionsIn this neonate, a small retained paravertebral catheter fragment was identified incidentally and was safely managed with conservative observation. When such fragments are non-metallic, stable, and located away from critical structures, non-operative management with close follow-up may be an appropriate and safe approach.